Datenblatt-Suchmaschine für elektronische Bauteile
  German  ▼
ALLDATASHEETDE.COM

X  

FAN5037 Datenblatt(PDF) 8 Page - Fairchild Semiconductor

Teilenummer FAN5037
Bauteilbeschribung  Adjustable Switching Regulator Controller
Download  11 Pages
Scroll/Zoom Zoom In 100%  Zoom Out
Hersteller  FAIRCHILD [Fairchild Semiconductor]
Direct Link  http://www.fairchildsemi.com
Logo FAIRCHILD - Fairchild Semiconductor

FAN5037 Datenblatt(HTML) 8 Page - Fairchild Semiconductor

Back Button FAN5037 Datasheet HTML 3Page - Fairchild Semiconductor FAN5037 Datasheet HTML 4Page - Fairchild Semiconductor FAN5037 Datasheet HTML 5Page - Fairchild Semiconductor FAN5037 Datasheet HTML 6Page - Fairchild Semiconductor FAN5037 Datasheet HTML 7Page - Fairchild Semiconductor FAN5037 Datasheet HTML 8Page - Fairchild Semiconductor FAN5037 Datasheet HTML 9Page - Fairchild Semiconductor FAN5037 Datasheet HTML 10Page - Fairchild Semiconductor FAN5037 Datasheet HTML 11Page - Fairchild Semiconductor  
Zoom Inzoom in Zoom Outzoom out
 8 / 11 page
background image
FAN5037
PRODUCT SPECIFICATION
8
REV. 1.0.3 9/26/01
where TF = Tolerance Factor for the sense resistor and 0.6A
accounts for the inductor ripple current.
Since the value of the sense resistor is often less than 10m
Ω,
care should be taken in the layout of the PCB. Trace resis-
tance can contribute significant errors. The traces to the
IFBH and IFBL pins of the FAN5037 should be Kelvin con-
nected to the pads of the current-sense resistor. To minimize
the influence of noise, the two traces should be run next to
each other.
Schottky Diode
In Figure 1, MOSFET Q1 and flyback diode D1 are used as
complementary switches in order to maintain a constant cur-
rent through the output inductor L2. As a result, D1 will have
to carry the full current of the output load when the power
MOSFET is turned off. The power in the diode is a direct
function of the forward voltage at the rated load current dur-
ing the off time of the FET. The following equation can be
used to estimate the diode power:
where ID is the forward current of the diode, VD is the for-
ward voltage of the diode, and DutyCycle is defined the
same as
For the Motorola MBRB1545CT Rectifier in Figure 1,
It is recommended that the diode T0-220 package be
attached to a heatsink.
Board Design Considerations
MOSFET Placement
Placement of the power MOSFET is critical in the design of
the switch-mode regulator. The MOSFET should be placed
in such a way as to minimize the length of the gate drive path
from the FAN5037 SDRV pin. This trace should be kept
under 0.5" for optimal performance. Excessive lead length
on this trace will cause high frequency noise resulting from
the parasitic inductance and capacitance of the trace. Since
this voltage can transition nearly 12V in around 100nsec, the
resultant ringing and noise would be very difficult to sup-
press. This trace should be routed on one layer only and kept
well away from the “quiet” analog pins of the device: CEXT,
IFBH, IFBL, and GND. Refer to Figure 2. A 4.7
Ω resistor in
series with the MOSFET gate can decrease this layout criti-
cality. Refer to Figure 1.
Inductor and Schottky Diode Placement
The inductor and fly-back Schottky diode need to be placed
close to the source of the power MOSFET for the same rea-
sons stated above. The node connecting the inductor and
Schottky diode will swing between the drain voltage of the
FET and the forward voltage of the Schottky diode. It is rec-
ommended that this node be converted to a plane if possible.
This node will be part of the high current path in the design,
and as such it is best treated as a plane in order to minimize
the parasitic resistance and inductance on that node. Since
most PC board manufacturers utilize 1/2 oz copper on the
top and bottom signal layers of the PCB, it is not recom-
mended to use these layers to route the high current portions
of the regulator design. Since it is more common to use 1 oz.
copper on the PCB inner layers, it is recommended to use
those layers to route the high current paths in the design.
P
DIODE
I
D
V
D
1
DutyCycle
()
×
×
=
Duty Cycle
Vout
Vin
-------------
=
P
DIODE
10A
0.65
1
73.1%
()
×
×
1.75W
==
Figure 3. Examples of good and poor layouts
5
6
7
8
5
= "Quiet" Pins
6
7
4
3
2
81
4
3
2
1
Example of
a Good Layout
Example of
a Problem Layout
Noisy signal radiates
onto quiet pins and the
trace is too long.
Gate resistor is far away
from the MOSFET.
Noisy signal is routed
away from quiet pins and the
trace length is kept under 0.5in.
The gate resistor is as close
as possible to the MOSFET.


Ähnliche Teilenummer - FAN5037

HerstellerTeilenummerDatenblattBauteilbeschribung
logo
Fairchild Semiconductor
FAN5037 FAIRCHILD-FAN5037 Datasheet
101Kb / 11P
   Adjustable Switching Regulator Controller
FAN5037 FAIRCHILD-FAN5037 Datasheet
106Kb / 11P
   Adjustable Switching Regulator Controller
FAN5037M FAIRCHILD-FAN5037M Datasheet
106Kb / 11P
   Adjustable Switching Regulator Controller
More results

Ähnliche Beschreibung - FAN5037

HerstellerTeilenummerDatenblattBauteilbeschribung
logo
Fairchild Semiconductor
FAN5037 FAIRCHILD-FAN5037 Datasheet
101Kb / 11P
   Adjustable Switching Regulator Controller
RC5037 FAIRCHILD-RC5037 Datasheet
81Kb / 12P
   Adjustable Switching Regulator Controller
FAN5037M FAIRCHILD-FAN5037M Datasheet
106Kb / 11P
   Adjustable Switching Regulator Controller
logo
Fujitsu Component Limit...
MB3775 FUJITSU-MB3775 Datasheet
485Kb / 25P
   SWITCHING REGULATOR CONTROLLER
logo
Seiko Instruments Inc
S-8533A125FT-TB-X SII-S-8533A125FT-TB-X Datasheet
1Mb / 33P
   SWITCHING REGULATOR CONTROLLER
logo
Agamem Microelectronic ...
AA18380 AGAMEM-AA18380 Datasheet
489Kb / 14P
   Switching Regulator Controller
logo
Fujitsu Component Limit...
MB3776A FUJITSU-MB3776A Datasheet
148Kb / 16P
   Switching Regulator Controller
MB3788 FUJITSU-MB3788 Datasheet
750Kb / 21P
   SWITCHING REGULATOR CONTROLLER
logo
Hitachi Semiconductor
HA17524P HITACHI-HA17524P Datasheet
88Kb / 18P
   Switching Regulator Controller
logo
Fujitsu Component Limit...
MB3769A FUJITSU-MB3769A_06 Datasheet
938Kb / 29P
   SWITCHING REGULATOR CONTROLLER
More results


Html Pages

1 2 3 4 5 6 7 8 9 10 11


Datenblatt Download

Go To PDF Page


Link URL




Privatsphäre und Datenschutz
ALLDATASHEETDE.COM
War ALLDATASHEET hilfreich?  [ DONATE ] 

Über Alldatasheet   |   Werbung   |   Kontakt   |   Privatsphäre und Datenschutz   |   Linktausch   |   Hersteller
All Rights Reserved©Alldatasheet.com


Mirror Sites
English : Alldatasheet.com  |   English : Alldatasheet.net  |   Chinese : Alldatasheetcn.com  |   German : Alldatasheetde.com  |   Japanese : Alldatasheet.jp
Russian : Alldatasheetru.com  |   Korean : Alldatasheet.co.kr  |   Spanish : Alldatasheet.es  |   French : Alldatasheet.fr  |   Italian : Alldatasheetit.com
Portuguese : Alldatasheetpt.com  |   Polish : Alldatasheet.pl  |   Vietnamese : Alldatasheet.vn
Indian : Alldatasheet.in  |   Mexican : Alldatasheet.com.mx  |   British : Alldatasheet.co.uk  |   New Zealand : Alldatasheet.co.nz
Family Site : ic2ic.com  |   icmetro.com